Fire stopping in Whiteford
Fire-rated and intumescent sealing of service penetrations and linear gaps in Whiteford and across Aberdeenshire. CHAS accredited, Constructionline member, with a 12-month guarantee on workmanship.
- Unsealed joints where partitions meet the slab
- Snag lists that include open service penetrations
- Openings found when ceilings come down for a refit
Fire stopping for Whiteford sites
Tell us what needs sealing and where, with photos or drawings if you have them, and we’ll price it.
Fire stopping in Whiteford
Penetration seals are fire tested to BS EN 1366-3 and linear joint seals to BS EN 1366-4, with results classified under BS EN 13501-2. That classification, such as EI 60 or EI 120, belongs to the product in its tested arrangement. So our job is to reproduce that arrangement faithfully. If you are dealing with penetration schedules that need working through and old intumescent sealant that has split away, we can put it right, on joints between fire-resisting walls and floors, small duct penetrations where the tested detail allows and linear gaps at wall heads alike. A single leaking joint is often how a building in Whiteford first comes to us: we look at the rest while we are there and tell you what we find.
Refurbishments in small hotels, schools and care homes around places like Whiteford can leave gaps around new services. A round of checks after M&E work is good practice, and any gaps found are sealed where fire-rated sealant is specified.
We stand by our work: 12 months, guaranteed. It covers how we prepared and applied the sealant, and if something we did falls short, we return to it.
- Where
- Whiteford (AB51)
- Region
- Aberdeenshire
- Cover
- 12 months on our workmanship
- Quote
- Fixed quote, scope in writing
- Phone
- 01277 525 020
- Page updated
- 3 November 2026
How the quote is worked out
Sealant work doesn’t have a standard rate, since sites vary so much. What we take into account:
- How much existing material needs removing
- How much there is to seal
- Phasing around occupants
- Site requirements such as inductions and permits
Whether it’s a single area or a whole estate, the same things set the price: what’s in scope, how we reach it, what’s specified and when it needs doing. Call for a quote, and you will have a fixed figure to work with.
Details that help us quote
Good information means a firmer quote. Helpful details to send:
- Whether the building will be occupied during the work
- The asbestos register, for older buildings
- Where the site is, with the postcode
- Any dates the work must fit around
Quotes are fixed against the scope you send, so the cost is agreed before work starts. To start the process, give us a call on 01277 525 020 or email us.
Should maintenance staff do it?
Some joints are best left to specialists: fire-rated seals that must follow a tested detail, trafficked floor joints and external movement joints among them. Getting these wrong usually costs more in the end than doing them right.
Site maintenance staff can often handle a short internal joint. The usual problems come from preparation: new sealant over old, damp or dusty faces, or the wrong product for the movement.
When something else is needed
Honesty saves time and money. New sealant won’t cure:
- Deciding what a wall or floor needs, which belongs to the designer
- Approving the work on behalf of building control
- Construction that lacks the fire resistance the seal relies on
If in doubt, phone 01277 525 020 or email drawings and photos and we will say what we think.
What we seal
- Small duct penetrations where the tested detail allows
- Linear gaps at wall heads
- Cable penetrations
- Service gaps in risers
- Joints between fire-resisting walls and floors
- Pipe penetrations
Common questions from Whiteford clients
What do Scotland’s building standards say about service penetrations in Whiteford?
The non-domestic Technical Handbook, clause 2.1.14, expects a penetration to keep at least the wall or floor’s fire resistance period, with proprietary products tested for the use they’re put to. We install what has been specified, to the manufacturer’s tested detail, while design and approval sit with the designer and the verifier.
Do you work on fire-rated sealing in hotels in Whiteford?
Yes, where the specification calls for fire-rated sealant. It goes in to the manufacturer’s tested detail for the wall or floor and the services passing through, and we’ll tell you if the detail calls for a collar, wrap or batt instead.
Are you CHAS accredited?
Yes. CHAS accredited, Constructionline member, and our applicators hold CSCS cards.
Do you work in Whiteford?
Yes. Whiteford is in our area and the rest of Aberdeenshire. For a quote, phone 01277 525 020 or use the quote form.
Is the work guaranteed?
Yes. The 12-month guarantee covers our preparation and application, but not damage, misuse or other trades’ work.
Can you handle several sites?
Yes. We take on portfolio and planned maintenance work, with each site phased to suit its occupants.
How do you deal with asbestos in old sealant?
Managing asbestos is the dutyholder’s responsibility, so we will ask for the register before work on an older building. Work pauses if suspect material is found, until it has been tested.
Work for main contractors and building owners
As a CHAS accredited contractor and Constructionline member, we make supplier vetting simple. Our insurance certificate can be sent along with the quote.
If you look after buildings for someone else, you need clear quotes and clear reporting. You get a fixed quote, an agreed scope and a walk round at the end.
Towns and villages near Whiteford
What else we do in Whiteford
How a job runs
A typical day starts with protection: tape along each joint edge and covers over finishes, stock and equipment close by. The work itself normally takes anything from one day to a planned run of visits, depending on the number of seals and the access, and our waste is bagged and taken away as we go. For a building near Whiteford, directions, keys and a contact on the day are worth sorting early. That goes into the plan alongside the quote.
- We start with your penetration schedule, drawings or specification.
- We plan the sequence of floors, risers and voids with you.
- We compare every service penetration with its tested detail before sealing.
- Unsuitable material is removed and the opening cleaned so the seal starts clean.
- The specified backing and sealant go in to depth and are finished neatly.
- Anything outside the detail is reported to you rather than sealed.
What we need from you
- Tell staff and tenants when we will be in
- Send asbestos survey details if the building is pre-2000
- Point out parking and an unloading spot
Get a fixed quote
A handful of photos and a postcode is the fastest way to a quote. Upload them with the quote form, or call 01277 525 020 or send details through our quote form to discuss it first.
Advice
What happens if it’s left?
A seal that doesn’t match its tested detail gives false comfort. Correcting it means cutting it out and starting again with the specified product. Renewing every failing joint on one visit is the sensible approach for a place like Whiteford. Photos of each area help us quote the whole job.
Access can matter as much as the joints themselves: joints within easy reach take less time than ones that need access equipment. Tell us how the joints are reached and call for a quote.
Why clients in Whiteford choose us
- Commercial sealant work since 2005
- Health and safety: CHAS accredited
- Workmanship guaranteed for 12 months
- Fully insured
See how commercial sealant jobs are priced or how we’re accredited.
Penetration seals near Whiteford
Scottish guidance (non-domestic Technical Handbook, clause 2.1.14) asks that penetrations match at least the fire resistance period of the element they pass through, and products should be tested for their end use. Where fire-rated sealant is specified, that’s what we install, to the tested detail. The area within 2 miles of Whiteford holds a number of hotels. Bedroom-to-corridor walls in hotels are normally fire-resisting, so new cabling or pipework through them has to be sealed to the tested detail.
In a building such as Old Parish Church, any service penetration through a fire-resisting wall should be sealed to the specified detail. For a hospital such as House Of Daviot Hospital, 1.9 miles north-east of Whiteford, penetration sealing is normally phased ward by ward, with infection-control rules agreed first.
Whiteford is about 4 miles north-west of Inverurie, in Aberdeenshire. Any commercial site in Whiteford is covered, whether it’s a single job or part of a planned programme. Whiteford is one of 179 places we cover in Aberdeenshire. There’s a separate page for Aberdeen, roughly 18 miles from Whiteford.
Commercial sites across AB51 are covered for service penetrations. If your site is on Whiteford Place, Whiteford Road and Whiteford Gardens or close by, send details and we’ll quote for service penetrations. Sites close to Whiteford are covered too, including Pitcaple (1 mile south-east), Chapel of Garioch (1 mile south), Daviot (2 miles north-east), Meikle Wartle (3 miles north) and Oyne (3 miles west). Bigger towns within reach include Inverurie (4 miles south-east), Westhill (13 miles south-east), Ellon (15 miles east), Turriff (15 miles north), Huntly (15 miles north-west) and Garioch (4 miles south-east). For island and remote sites, we plan travel and materials carefully, so the full address helps from the start.
Landmarks near Whiteford
Whiteford’s nearest station is Inverurie station, roughly 4.4 miles south-east. Nearby you’ll also find Pitcaple Castle (0.5 miles east) and House Of Daviot Hospital (1.9 miles north-east).