Fire-rated sealing and fire stopping in Chiltington, East Sussex
Fire stopping for Chiltington, from a contractor working since 2005. Fully insured, with a 12-month guarantee.
- Seals that don’t match their tested detail
- Seals disturbed by maintenance and left open
- Penetration schedules that need working through
Fire stopping near Chiltington
Photos, a specification or a quick description of the joints is enough to start a fixed quote.
How the quote is worked out
To price the job, we consider:
- Whether the work must be split into stages
- Site requirements such as inductions and permits
- Specialist products, such as fire-rated or hygienic sealants
- How accessible the joints are
The price depends on how many linear metres there are, what has to come out first and the access. Call for a fixed quote when you are ready.
Before you send an enquiry
A few photos plus some basic facts will normally do. Please tell us:
- Where the site is, with the postcode
- The type of building and who uses it
- Any dates the work must fit around
- The product your specification calls for
The quickest route to a quote is a few photographs and the site postcode. Send them through the quote form, or give us a call on 01277 525 020 or email a schedule or drawings to discuss it first.
About our fire stopping in Chiltington
A fire-rated sealant is only one part of a tested system: its test evidence covers one product in one kind of wall or floor, with set services, gaps, depths and backing. We match each opening to that detail before any sealant goes in, and raise it with you if it falls outside. If you have unsealed openings around new pipes and cables and openings found when ceilings come down for a refit, we can put it right. One point of contact handles commercial sealant work in Chiltington from the first photographs to the final walk-round, whether it’s one building or several.
Rural conversions around Chiltington can put new fire-resisting partitions inside older structures. Where a pipe or cable passes through a fire-resisting wall, the seal must match the tested detail: product, substrate, gap and depth.
We stand behind the joints we seal: 12 months, guaranteed. It covers how we prepared and applied the sealant.
- Where
- Chiltington (BN7)
- Wider area
- East Sussex
- Cover
- 12 months on every job
- Quotes
- A fixed quote before we start
- Call
- 01277 525 020
- Last updated
- 3 November 2026
Also near Chiltington
What else we do in Chiltington
Compartments and services around Chiltington
Fire stopping of openings and penetrations in England falls under Approved Document B. Its BS 476 references are being withdrawn from 2 September 2029, with BS EN 13501-2 classification taking over, subject to transitional arrangements. What we install is set by the specification, and it goes in to the tested detail. Central London is about 40 miles from Chiltington. Tenant changes on commuter-belt business parks mean regular fit-outs, and new services through compartment walls.
For a hospital such as Lewes Victoria Hospital, which lies south of Chiltington, penetration sealing is typically phased ward by ward, with infection-control rules agreed first. Halls and meeting rooms at places like The Parish Church sometimes gain new services, and any compartment wall crossed needs the specified seal.
Chiltington is about 3 miles north-west of Lewes, in East Sussex. Our applicators travel to Chiltington for work on service penetrations, handled exactly as we handle every other area. We work across 308 places in East Sussex, from busy centres to rural villages. For work in that direction, see our Brighton page.
Commercial sites across BN7 are covered for service penetrations. Just outside Chiltington, we also work in East Chiltington (1 mile west), Cooksbridge (1 mile south-east), South Chailey (1 mile north), Plumpton (2 miles south-west) and Plumpton Green (2 miles north-west). Bigger towns within reach include Seaford (12 miles south-east), Lewes (3 miles south-east), Hailsham (13 miles east), Crowborough (12 miles north-east), Uckfield (7 miles north-east) and Newhaven (9 miles south).
Local landmarks in Chiltington
Chiltington’s nearest station is Cooksbridge station, about 1.3 miles south-east. Nearby you will also find Lewes Castle (3.5 miles south-east) and Ditchling Museum of Art + Craft (3.9 miles west). The countryside around Chiltington includes Blackcap and Malling Down.
How the job changes by surface
Drylining partitions
Plasterboard partitions are tested as a specific construction. The sealant detail has to be tested in that wall type, with the stated board layers first.
Masonry and concrete
Openings through concrete vary from tidy cores to rough break-outs. The gap is measured at the widest point against the detail’s limits.
When something else is needed
Honesty saves time and money. New sealant won’t cure:
- Issuing fire ratings or certificates for seals
- Writing the fire-stopping specification
- Openings that need collars, wraps, batts or boards rather than sealant
If in doubt, phone 01277 525 020 or send photos by email and we will say what we think.
Joints and surfaces we work on
- Joints between fire-resisting walls and floors
- Small duct penetrations where the tested detail allows
- Cable penetrations
- Pipe penetrations
- Linear gaps at wall heads
- Service gaps in risers
Doing it in-house
For most general trades, sealant is a sideline. A specialist brings correct preparation, depth control with backing rod and a product suited to that particular joint.
Putting right a botched joint often costs more than sealing it well at the start, since all of it has to come out and the faces be cleaned back again. For that reason, many FMs and contractors use a sealant specialist from the outset.
Questions we are asked in Chiltington
What happens to BS 476 references for fire stopping in Chiltington?
References to BS 476 classes are being removed from Approved Document B from 2 September 2029, after which BS EN 13501-2 classification is the route, subject to transitional arrangements. The designer or fire engineer sets the specification, and we install the product to the manufacturer’s tested detail.
Is hospital work, at somewhere like Lewes Victoria Hospital, something you do?
Yes. Healthcare sites are among the places we work. Work is phased so departments keep running, under the site’s own rules.
Which sealant will you use?
If the job is specified, we follow the specification. If not, we choose for the movement, the surfaces and the conditions, in line with the manufacturer’s guidance.
Is the work guaranteed?
Yes. Our workmanship is backed for 12 months on every job.
Can you fit around our working hours?
We’re in the office from 8am until 5pm, Monday to Friday. Tell us your site hours and access windows and the work will be fitted around them.
How long does a job like this take?
The duration is planned around your programme and the access we are given. We’ll give you an estimate of time on site when we quote.
How do we ask for a quote?
The quote form is the simplest route, though you can also call 01277 525 020 or email drawings and photos. Include photos or drawings if you have them.
How a job runs
We schedule the visit to fit the site hours and access windows you give us. While we are working, the area stays contained and tidy, and we check in with your contact before moving on to each new area. If others near Chiltington need work, visits can be combined, which keeps travel down. A fixed quote is given before anything starts.
- First we go through the drawings, schedule or specification for the seals.
- On site, each opening is checked against the tested detail it is meant to follow.
- Unsuitable fillers and loose debris are taken out of each opening.
- Mineral wool or other backing goes in wherever the detail asks.
- Fire-rated or intumescent sealant is gunned in to the specified depth, then tooled.
- Openings that need a collar, wrap, batt or other product are flagged to you rather than filled with sealant.
Getting the site ready
- Send your site hours and access windows
- Confirm the product named in the specification
- Send asbestos survey details if the building is pre-2000
Getting a fixed quote
Send details, get a quote, we seal, guaranteed: that’s how every job runs. To take the first step, call the office on 01277 525 020 or use the quote form.
Advice
What we’re called out for in Chiltington
Damage plays a part too. Seals get knocked during maintenance, cut back to add a cable or pulled out when services are swapped and the opening isn’t always resealed.
Clients typically get in touch after noticing one or more of the following:
- Openings found when ceilings come down for a refit
- Unsealed joints where partitions meet the slab
- Fire sealant pulled out of the opening
- Fire seals cut back for extra cables and never reinstated
For a school such as Chailey School, penetration sealing fits best at the end of the summer works.
What to look for in a quote
- Their public liability cover
- Is the sealant right for the movement and the substrate?
- How they’ll work around occupants
- Will failed sealant be removed rather than covered?