Fire-rated sealing and fire stopping in Woodmancote, West Sussex
Work needed on a service penetration in Woodmancote? We look at it, seal it with the right product and hand it over with a 12-month guarantee.
- Seals disturbed by maintenance and left open
- Snag lists that include open service penetrations
- Unsealed penetrations discovered above suspended ceilings
Fire stopping across Woodmancote
Tell us what needs sealing and where, with photos or drawings if you have them, and we’ll price it.
Fire stopping in Woodmancote
On a fit-out or refurbishment, we follow the services contractors floor by floor. To price a package, give us a call on 01277 525 020 or send photos by email with the schedule or marked-up drawings and the specified product data. Tell us what records you need and we will confirm with the quote. Site teams most often ask us about expanding foam used as fire stopping and unsealed joints where partitions meet the slab, on small duct penetrations where the tested detail allows, service gaps in risers and cable penetrations. One point of contact handles commercial sealant work in Woodmancote from the first photographs to the final walk-round, whether it’s one building or several.
For a smaller site near Woodmancote, we plan to do all the penetrations in one go, so send the specification and photos first. We install to the specification and the manufacturer’s guidance, leaving design and sign-off with the designer and building control.
Whoever the client is, the cover is the same: a 12-month guarantee on our workmanship. It doesn’t extend to damage, faults in the building or work by others, and we’re upfront about that.
- Location
- Woodmancote (PO10)
- Region
- West Sussex
- Guarantee
- 12 months on our workmanship
- Quotes
- A fixed quote before we start
- Telephone
- 01277 525 020
- Updated
- 3 November 2026
How the job changes by surface
Plastic pipes
Plastic pipes soften and collapse in a fire. Small sizes are sometimes covered by an intumescent sealant detail. We check the pipe material and diameter against the detail before we start.
Small ducts
Small ductwork can sometimes be sealed with sealant where the tested detail includes it. Larger or fire-rated ductwork normally needs a different solution set by the designer and we flag that rather than guess.
Also near Woodmancote
Also in Woodmancote
How a job runs
At the end of each section, we remove the tape, clean down and inspect every joint, ready for your sign-off. If an area should be left alone while the sealant cures, we say how long and put signs out. Jobs in and around smaller places like Woodmancote are typically planned as a single visit, so photographs and measurements up front really help. Then the right materials arrive with us.
- We read the specification, drawings or penetration schedule you send.
- On site, each opening is checked against the tested detail it is meant to follow.
- Anything that doesn’t belong in the opening, such as expanding foam or general-purpose filler, is removed.
- Mineral wool or other backing goes in wherever the detail asks.
- We apply the specified sealant to the depth and around the services as the detail shows.
- Openings that need a collar, wrap, batt or other product are flagged to you rather than filled with sealant.
Preparing the site
- Tell staff and tenants when we will be in
- Explain the parking and delivery arrangements
- Tell us which areas need to stay in use
Getting a fixed quote
Tell us about the building, the joints and when you need the work done, and we’ll put a fixed quote together. To get it moving, phone 01277 525 020 or email a schedule or drawings.
Related advice
Maintenance after handover
Keep the joints in good shape with a few simple steps:
- Don’t let anyone top up a fire seal with the wrong product
- Ask which product is in place before decorating
- Keep product data and details in the fire safety file
- Look above ceilings when tiles are lifted for other jobs
Keep the product data and installation details with the building’s fire safety information. It makes later repairs much easier to match.
Write fire stopping into the scope of any work crossing a compartment wall or floor. Then the seal goes in while the area is open, not months later.
What we’re called out for in Woodmancote
Mixing products or improvising a detail breaks the link with the test evidence. Gaps beyond the tested size, shallow sealant, no backing where it was needed, or products from different systems mixed together are the usual culprits.
Common reasons buildings call us in:
- Fire-stopping items raised at inspection or handover
- Old intumescent sealant that has split away
- Improvised or mixed-product fire seals
- Open linear gaps along the top of fire-resisting walls
Hospital estates such as Spire Hospital Portsmouth, 2.3 miles west of Woodmancote, are divided into fire compartments, and any service penetration through them should be sealed to the specified, tested detail.
Before you book anyone
- What level of public liability insurance do they hold?
- Are they CHAS accredited or on Constructionline?
- How joint depth will be controlled
- Is the sealant right for the movement and the substrate?
What sets the cost
What shapes the price:
- Joint width, depth and condition
- Specialist products, such as fire-rated or hygienic sealants
- The total length or number of joints
- How accessible the joints are
No two sites price the same: the joint sizes, the specified product, access and working hours each have a bearing. A fixed quote follows once we understand the job.
Sending details for a quote
For an accurate fixed quote, we need a clear picture of the site. Send us:
- Your programme or deadline
- The site address and postcode
- A wide shot and a close-up of the area
- The product your specification calls for
If there’s a specification, drawings or a tender package, send it with your enquiry, and we will price against exactly what is specified. Smaller jobs need nothing more than photos and a few notes.
Fire stopping in Woodmancote: the local picture
The 2 miles around Woodmancote include two care or nursing homes. Care settings depend on compartmentation, so service penetrations made during maintenance or refurbishment need sealing with the specified product. The area within 2 miles of Woodmancote holds several hotels. Bedroom-to-corridor walls in hotels are normally fire-resisting, so new cabling or pipework through them has to be sealed to the tested detail.
For a building such as Woodmancote Church, new heating or data runs are the usual reason penetrations need sealing. On a site such as Hambrook Business Park, which lies east of Woodmancote, every fit-out that runs new services through a compartment wall leaves penetrations to seal with the specified product.
Woodmancote is about 4 miles east of Havant, in West Sussex. Anywhere in PO10, it works the same way: send details, get a fixed quote, we seal, and the work is guaranteed. Across West Sussex, 373 places are covered, including Woodmancote. Portsmouth is covered too, around 8 miles from Woodmancote.
Postcode districts covered here: PO10 for service penetrations. Among the streets we cover are South Lane, Duffield Lane and Woodmancote Lane. Close to Woodmancote, our area also takes in Westbourne (1 mile west), Southbourne (1 mile south), Lumley (1 mile south-west), Emsworth (2 miles south-west) and Denvilles (3 miles west). A short drive away, we cover Bognor Regis (11 miles south-east), Chichester (6 miles east), Selsey (10 miles south-east), Portfield (6 miles east), Yapton (13 miles east) and East Wittering (7 miles south).
Landmarks near Woodmancote
We work on buildings around The Stag's Head Public House, Westbourne Primary School and Stansted Park, among other places. The nearest railway station is Southbourne station, about 0.9 miles south of the centre. Other landmarks nearby include Havant War Memorial Hospital (3.7 miles west) and Warblington Castle (2.9 miles south-west). Not far away are Stoke Down and Brook Meadow (Emsworth).
What happens if it’s left?
Sealing behind the M&E trades area by area beats a sweep at the end. Openings are visible, access is open and nothing has to be taken down and each detail can be checked as we go. For buildings around smaller places like Woodmancote, water damage can go unnoticed for longer, especially where a building isn’t used daily, so a failed joint can leak for a while before anyone sees it. Renewing joints in good time avoids the problem.
The price depends on the quantity of joints, how much old material needs removing and how the joints are reached. Call for a fixed quote when you’re ready.
What you get with us
- Constructionline member for supplier checks
- Sealing commercial buildings since 2005
- Fully insured, including public liability cover
- Joints cleaned back to sound surfaces
Take a look at how commercial sealant jobs are priced and our accreditations.
FAQs: Woodmancote
Can you work at a site such as Hambrook Business Park, by Woodmancote?
Yes. Our area takes in Woodmancote and its surroundings, with estates and business parks such as Hambrook Business Park included. To start, just ring 01277 525 020 or email us with the unit, the joints involved and your access times.
What happens to BS 476 references for fire stopping in Woodmancote?
From 2 September 2029, Approved Document B drops its BS 476 references in favour of BS EN 13501-2 classification, with transitional arrangements. Our part doesn’t change: the specified product, to its tested detail.
Do you take on multi-site work?
Yes. We take on portfolio and planned maintenance work, with each site phased to suit its occupants.
How many days will you need on site?
The duration is planned around your programme and the access we are given. You’ll have an expected duration with the quote.
Will you quote for a small job?
Whatever the size, the process is the same: send details, get a fixed quote, we seal, guaranteed.
Who decides which product is used?
Where there’s a specification, we use the product it names. Otherwise, we recommend a product to suit the joint’s movement, the substrate and the conditions, following the manufacturer’s guidance.
Are your applicators CSCS-carded?
Yes. If you need card details for site access, tell us and we’ll confirm them with the quote.