New Lanark fire stopping
Fire stopping in New Lanark, backed by over 20 years in commercial sealing. Fully insured and CHAS accredited.
- Builders’ foam or ordinary silicone in compartment walls
- Unsealed openings around new pipes and cables
- Fire-rated sealant that has cracked or shrunk back
Fire stopping in New Lanark
Send drawings, photos or a joint schedule, or tell us about the site, and we’ll come back with a fixed quote.
Fire stopping for commercial buildings in New Lanark
A fire-rated sealant is only one part of a tested system: the evidence covers a specific product, wall or floor type, service, gap, depth and backing. We match each opening to that detail before any sealant goes in, and raise it with you if it falls outside. The enquiries we see most involve fire stopping installed outside its tested range and fire seals cut back for extra cables and never reinstated, on cable penetrations, service gaps in risers and joints between fire-resisting walls and floors. Looking for mastic applicators who cover New Lanark? Mastic Doctor has worked for contractors, FMs and building owners since 2005, with CSCS-carded applicators.
In smaller Scottish places like New Lanark, buildings with fire-resisting walls typically include schools, care homes, hotels and health centres. Where services pass through, specified fire-rated sealant is installed following the manufacturer’s guidance for that wall or floor.
The 12-month guarantee covers our workmanship: the preparation, the sealing and the tooling. It doesn’t extend to damage, other trades’ later work or movement the joint was never designed to take.
- Where
- New Lanark (ML11)
- Region
- South Lanarkshire
- Guarantee
- 12 months on every job
- Quote
- Fixed quote, scope in writing
- Telephone
- 01277 525 020
- Page updated
- 3 November 2026
New Lanark: questions and answers
How do Scotland’s building standards affect fire-rated sealant in New Lanark?
Under Scotland’s non-domestic Technical Handbook (clause 2.1.14), service penetrations should keep at least the wall or floor’s fire resistance duration, using products tested for their end use. Design sits with the designer and the verifier; installation to the tested detail is our part.
Can you work on a hospital site such as Lockhart Hospital?
Yes, provided the work is planned with the site’s estates team. The estates team’s permit system and infection-control rules come first, and the work is planned around them.
Is your workmanship covered by a guarantee?
Yes. It runs for twelve months and covers how we prepared and sealed the joints, though not damage or work by other trades.
Can you work while the building is occupied?
Yes, as long as we plan it. We agree a sequence with your contact so just one area at a time is disrupted.
Can you send site paperwork?
Tell us what site paperwork you need (RAMS, insurance certificate, CSCS details) and we will confirm with the quote.
Do you offer coloured sealant?
Often, yes. Sealants are made in a wide range of standard colours, and matching to RAL references or nearby finishes is commonly requested. We’ll confirm the colours available for the specified product.
When is resealing likely to be due?
It depends on movement, UV and weather, cleaning, traffic and the product. Treat them as maintenance items and inspect them regularly.
Places near New Lanark
Other services in New Lanark
When to bring in a specialist
Certain joints really need a specialist: fire-rated seals that must follow a tested detail, trafficked floor joints and external movement joints among them. Getting these wrong usually costs more in the end than doing them right.
The visible bead is only part of the job. Correct depth, the right primer and a sealant matched to the movement are where general trades tend to cut corners.
Why deal with it now?
An improvised seal can look finished while offering no tested performance. Correcting it means cutting it out and starting again with the specified product, so it makes sense to get it right first time. Buildings that aren’t in daily use, such as halls and seasonal premises, may let water in unnoticed, so a failed joint has time to cause damage. Resealing early avoids that.
The specified product makes a difference, and so does the preparation. Access, phasing and site requirements come into it too.
Why choose Mastic Doctor in New Lanark
- A fixed quote before work starts
- One phone line for London, the South East and Scotland
- A Constructionline member, so easy to vet
- Our applicators hold CSCS cards
Take a look at what affects the cost or our accreditations.
Keeping the joints sound
Cleaning and maintenance staff play a part too. Share these points with them:
- Look above ceilings when tiles are lifted for other jobs
- Report damaged or disturbed seals as soon as they’re spotted
- Record which product was used where
- Brief every trade that openings they make must be sealed
New services after handover are a common way fire stopping gets breached. Building it into each contractor’s sign-off keeps the walls intact.
Regular walk-rounds of service areas are worth the time. A cracked or disturbed seal found early is a small job.
Fire stopping around New Lanark: how the place shapes the job
Scottish guidance (non-domestic Technical Handbook, clause 2.1.14) asks that penetrations match at least the fire resistance period of the element they pass through, with proprietary products, intumescent ones included, tested for their end use. Where fire-rated sealant is specified, that’s what we install, to the tested detail. There are a number of hotels within about 2 miles of New Lanark. Bedroom-to-corridor walls in hotels are normally fire-resisting, so new cabling or pipework through them has to be sealed to the tested detail.
On a hospital site such as Lockhart Hospital, 0.9 miles to the north-east of New Lanark, fire-rated sealant goes in where the specification calls for it, with the work planned around the estates team’s permits. Shop fits on retail sites such as Braidfute Retail Park, 0.7 miles north-east of New Lanark, can bring new services through fire-resisting walls between units, to be sealed with the specified product. For a hotel such as New Lanark Mill Hotel, under half a mile to the west of New Lanark, penetration seals are worth checking after any refit or services upgrade.
New Lanark is about 1 mile south of Lanark, in South Lanarkshire. Businesses, contractors and managing agents in New Lanark use us for work on service penetrations. New Lanark is one of 134 places in South Lanarkshire on our list for service penetrations. Our Glasgow page has more on work in that area (23 miles or so).
Commercial sites across ML11 are covered for service penetrations. Streets here include Braxfield Road, New Lanark Road and Rosedale Street, and sites on any of them can send details for a fixed quote. We also cover Lanark (1 mile north), Kirkfieldbank (1 mile north-west), Nemphlar (2 miles north-west), Cleghorn (2 miles north-east) and Cartland (2 miles north). Bigger towns within reach include Hamilton (13 miles north-west), Blantyre (15 miles north-west), Larkhall (9 miles north-west), Carluke (5 miles north-west), Strathaven (11 miles west) and Bothwell (15 miles north-west).
What’s near New Lanark
We work on buildings around Castlebank Park and The Wee Man's pub and the streets around them. The nearest railway station is Lanark station, roughly 0.8 miles north-east of the centre. Other landmarks nearby include William Smellie Memorial Hospital (1 mile north) and New Lanark Visitor Centre (under half a mile south-east). Green spaces nearby include Lanark Loch and Black Hill.
How the quote is worked out
There’s no standard rate for sealant work, since sites vary so much. What we take into account:
- Backing rod, priming and other preparation
- Location, for remote and island sites
- The site’s rules and procedures
- Removal of failed or old sealant
We don’t publish prices, because the scope varies so much from one building to the next. Call for a quote.
Details that help us quote
It doesn’t need to be a full survey. These details are enough to start:
- Asbestos survey details if the building is older
- Any dates the work must fit around
- Whether the building will be occupied during the work
- Photos of the joints, close up and from further back
To get a fixed quote, call 01277 525 020 or send details through our quote form. Our quote form is another easy route.
For managing agents and facilities managers
If you look after buildings for someone else, you need clear quotes and clear reporting. We quote a fixed sum, confirm the scope and walk the finished work with you or your representative.
Facilities managers want contractors who arrive with the paperwork sorted. Let us know the documents you need (RAMS, insurance certificate, CSCS details) and we’ll confirm them with the quote.
On site: what to expect
Where the site stays busy, we agree a sequence with your contact so the disruption stays in one area at once. Each section is protected, cleaned back and sealed, then reopened once the sealant allows before we move to the next. Travel to smaller Scottish places like New Lanark is planned so the job is finished in one visit where possible, which is why we ask for photographs and a full list first. Outside work also needs a suitable weather window.
- First we confirm the product and tested details named in the specification.
- Openings are measured and grouped by detail.
- Old or wrong materials are cut out.
- Mineral wool or other backing is fitted where required.
- We gun the sealant in to the specified depth around each service and tool it.
- Completed areas are checked with you, with the records agreed when we quoted.
Preparing the site
- Tell staff and tenants when we will be in
- Tell us your opening times and when work is allowed
- Flag any permit to work we’ll need
Getting a fixed quote
Tell us about the building, the joints and when you need the work done, and a fixed quote will follow. The easiest way is to call the office on 01277 525 020 or use the quote form.